GM Will Rework or Replace Keys on 187,972 Canadian Cars
OSHAWA – General Motors will rework or replace the ignition keys on 187,972 2000 to 2014 model year cars in Canada because the ignition switch may inadvertently move out of the “run” position if the key is carrying extra weight and experiences some jarring event.
The use of a key with a hole, rather than a slotted key, addresses the concern of unintended key rotation due to a jarring road event, such as striking a pothole or crossing railroad tracks.
The total North America population – U.S., Canada, Mexico and exports – is 3,360,555.
The safety recall follows a review of ignition issues following the recall in February of 2.6 million Chevrolet Cobalts and other small cars. GM is aware of eight crashes and six injuries related to this recall.
If the ignition switch moves out of the “run” position, there is an effect on power steering and power braking. In addition, the timing of the key movement out of the “run” position, relative to the activation of the sensing algorithm of the crash event, may result in the air bags not deploying.
The cars being recalled are the:
In these vehicles, the ignition switch may be unable to handle extra weight hanging on a slotted key. GM will add an insert to the ignition keys of the recalled vehicles to close the slot and leave a 4×6-millimeter hole through which the key ring could be attached. In vehicles where the key cover has been worn, new keys with holes instead of slots will be provided free of charge.
Rework of the keys – adding key inserts – at GM dealerships is expected to begin in the next few weeks. Until the rework or replacement is completed, owners of the recalled cars are urged to remove additional weight from their key chains and drive with only the ignition key.
In addition to the ignition key recall, GM also announced Canadian recalls for 13,764 vehicles in these four actions:
- 6,135 model year 2013-14 Cadillac ATS and 21,863 model year 2014 Cadillac CTS sedans. In certain vehicles with automatic transmissions, the shift cable may not be fully secured to the shifter bracket or transmission bracket. If the shift cable comes out of the brackets, the driver may not be able to shift the transmission in or out of gear. GM is unaware of any crashes or injuries related to this condition.
- 6,778 2015 Chevrolet Silverado 2500/3500 HD and 2015 GMC Sierra 2500/3500 GMC Sierra HD to inspect for proper attachment of power steering hose clamps to the power steering pump. If the vehicle is driven with the clamp unattached, the hose may disconnect from the pump or gear, causing a rapid loss of power steering fluid. This will result in loss of power steering assist and Hydro Boost powered brakes without warning. The vehicle would revert to manual brakes and manual steering. GM knows of no crashes or injuries from the condition. Dealers are to inspect power steering hose clamps in two locations to ensure they are properly attached.
- 790 model year 2011 Cadillac CTS sedans with AWD. On some vehicles, a gasket leak where the constant velocity joint meets the rear propeller shaft may cause the rear propeller shaft to separate or become loose, making contact with the vehicle floor above and causing the rollover sensor to deploy the roof rail air bags. GM is aware of 15 unintended deployments, but injury data is unclear.
- 61 model year 2014 Chevrolet Corvettes with optional Competition Sport Seats, because an unbelted child and door trim may block the passenger seat side air bag vent in a deployment. Dealers will replace the current air bag with a redesigned version. GM is unaware of any crashes or injuries related to this condition, but advises customers to not allow small children in the front seat until the vehicle is serviced.
GM expects to take a charge of up to approximately $700 million in the second quarter for the cost of recall-related repairs announced in the quarter. This amount includes a previously disclosed $400 million charge for recalls announced May 15 and May 20.
About General Motors in Canada
Headquartered in Oshawa, Ontario, General Motors of Canada Limited (GMCL) employs more than 9,000 people across the country and is a recognized leader in green manufacturing. GMCL markets the full range of fuel-efficient Chevrolet, Buick, GMC and Cadillac vehicles and related services through Canada’s largest automotive dealer network. More information regarding GMCL models can be found at www.gm.ca, or by following @GMCanada on Twitter.